3238422 - 5530A10 alternator - r+r

 Refer to op.. 5530A14  alternator - r+r for versions with air conditioner Removing ( Refitting ) Position the vehicle on the rampEnsure that the ignition key is in the OFF position, then disconnect the negative battery terminal (-).

	Name	Connector
-	Battery	A1B

Proceed with removal  - 4450B04  right front wheel r r . Proceed with removal  - 7055B54  under-engine guard - r r . Proceed with removal - 7055B91 Right front WHEEL ARCH LINER - R.R. . Proceed with removal - 7055B66 Engine compartment DUST SHIELD protection in right front wheel arch - R.R. . Proceed with removal  - 1092G10  single engine belt r r . 1. Undo the lower alternator fixing bolt. Proceed with removal  - 1076B70  exhaust pipe between pre-catalytic converter and catalytic converter - r r . 1. Position a hydraulic jack under the gearbox2. Undo the bolt fixing the rear power unit rigid support to the flexible mounting. Lower the hydraulic jack as necessary.3. Open the protective cover, undo the nuts (3a) and disconnect the electrical connections (3b) from the alternator.

	Name	Connector
3b	Alternator	A10

4. Undo the upper alternator fixing bolt.5. Remove the alternator Refitting ( Removing ) Place the alternator back in its housing and secure it tightening the bolts to the recommended torque.

	Fastening	Component	Ø	Value(daNm)
-	-	-	-	-

Connect the electrical connections to the alternator, secure them using the nuts and close the protective cover.Tighten the bolt securing the rigid rear power unit support to the flexible mounting to the recommended torque.

	Fastening	Component	Ø	Value(daNm)
-	-	-	-	-

Remove the hydraulic jack from under the gearbox. Proceed with refitting  - 1076B70  exhaust pipe between pre-catalytic converter and catalytic converter - r r . Proceed with refitting  - 1092G10  single engine belt r r . Proceed with refitting - 7055B66 Engine compartment DUST SHIELD protection in right front wheel arch - R.R. . Proceed with refitting - 7055B91 Right front WHEEL ARCH LINER - R.R. . Proceed with refitting  - 7055B54  under-engine guard - r r . Proceed with refitting  - 4450B04  right front wheel r r . Connect the negative (-) battery terminalRemove the car from the ramps.