5040A50 PIPE FROM COMPRESSOR TO AIR CONDITIONER CONDENSER - R+R - Alfa - GT - eLearn

125001527 - 5040A50 PIPE FROM COMPRESSOR TO AIR CONDITIONER CONDENSER - R+R

) Observe the following precaution.

Follow the safety instructions ( Op. 5040 AIR CONDITIONING CASING AND COMPONENTS).

Drain the refrigerant ( Op. 0010T84 COOLANT FOR AIR CONDITIONING SYSTEM DEHYDRATE AND RECHARGE). Op. 4450B02 LEFT FRONT WHEEL R R Op. 4450B04 RIGHT FRONT WHEEL R R Op. 7055B54 UNDER-ENGINE GUARD - R R Op. 7055B64 LH OR RH REFLECTOR(ONE) ON REAR BUMPERS - R R Op. 7055B65 ENGINGE BAY DUSTGUARD PROTECTION IN LEFT FRONT WHEEL ARCH R R Op. 7055B90 LEFT FRONT WHEEL ARCH LINER - R.R. Op. 7055B91 RIGHT FRONT WHEEL ARCH LINER - R.R. Op. 7210E10 R.R. FRONT BUMPER1. Undo the bolt and disconnect the connector (1a) for the pipe from the condenser (1b).

Seal the disconnected connectors, using suitable plugs, to prevent humidity and impurities from entering the system.

1. Lower the vehicle, then undo the nut fixing the intermediate coupling for the pipe from the climate control casing to the compressor.2. Disconnect the intermediate coupling.3. Undo the bolt and disconnect the connector for the pipe from the compressor.4. Remove the pipe.

Refitting ( Removing

) Check that the pipe is not damaged or cracked.Position the pipe.

Replace the O-rings for the connectors. Only use green coloured seals, resistant to R134A refrigerant. Lubricate the thread of the connectors using anti-freeze.

Connect the connectors for the pipe and tighten the bolts and the nut.

	Fastening	Component	Ø	Value(daNm)
-	Bolt	COOLANT SYSTEM FITTINGS	M6	0.9

	Fastening	Component	Ø	Value(daNm)
-	Nut	COOLANT SYSTEM FITTINGS	M6	0.9

Op. 7210E10 R.R. FRONT BUMPER Op. 7055B90 LEFT FRONT WHEEL ARCH LINER - R.R. Op. 7055B91 RIGHT FRONT WHEEL ARCH LINER - R.R. Op. 7055B65 ENGINGE BAY DUSTGUARD PROTECTION IN LEFT FRONT WHEEL ARCH R R Op. 7055B64 LH OR RH REFLECTOR(ONE) ON REAR BUMPERS - R R Op. 7055B54 UNDER-ENGINE GUARD - R R Op. 4450B02 LEFT FRONT WHEEL R R Op. 4450B04 RIGHT FRONT WHEEL R RRepressurize using refrigerant ( Op. 0010T84 COOLANT FOR AIR CONDITIONING SYSTEM DEHYDRATE AND RECHARGE).