169000091 - K81 AIRBAG WARNING LIGHT OFF / (DO NOT CARRY OUT INITIAL TEST)

To apply this procedure, the following must be borne in mind:1 - Measurements cannot be taken on the Air Bag wiring.2 - The system fault diagnosis is started leaving the vehicle charges connected.3 - The fault should be "Present" or "Present Intermittently" and not "Intermittent". If the fault is Intermittent then the Procedure is not applicable; proceed with an accurate check on the line where the fault was signalled.4 - Not all the simulation sensors are available (e.g. side impact sensors).

The Air Bag failure warning light is controlled directly through a dedicatec connection to the "Instrument Panel Node" from the Air Bag Control Unit.

The Air Bag wiring is a safety component. If there are problems with the cables or the connectors then the wiring should be replaced in one piece.

1	Fuse condition check	All OK	Problems encountered	Operation
	Turn the ignition key OFF.Check the condition of the bulb protective fuse	Move on to Step 2 1	The fuse is not intact	Replace the fuseDelete the errors using the diagnostic equipment and move on to Step 5
2	Electrical connections check	All OK	Problems encountered	Operation
	Check the continuity of the cable between the ignition switch and the protective fuse for the bulb    See E7030 AIRBAG	Move on to Step 3 3	The cable is broken	Restore continuity    See E7030 AIRBAGDelete the errors using the diagnostic equipment.Move on to Step 5
3	Check earth connection	All OK	Problems encountered	Operation
	Check the continuity of the cable between the instrument panel and the earth    See E7030 AIRBAG	Move on to Step 4	The cable is broken	Restore continuity    See E7030 AIRBAGDelete the errors using the diagnostic equipment.Move on to Step 5
4	Instrument panel replacement	All OK	Problems encountered	Operation
	Replace the instrument panel    Op. 5560B10 ANALOGUE CONTROL PANEL - R+RDelete the errors using the diagnostic equipment	Move on to Step 5
5	Correct operation check	All OK	Problems encountered	Operation
	Check that the diagnostic equipment is not signalling other faults	End of diagnosis	The diagnostic equipment is signalling other faults	Proceed as instructed in the    See table K80 AIRBAG FAILURE WARNING LIGHT ON