2891329 - 1088C10 water pump - r + r

Removing ( Refitting ) Place the car on a ramp.Open the bonnet lid.With the ignition key in the OFF position, disconnect the battery negative terminal. - 4450B10  Front WHEEL (one) - R.R.1. Place a container under the vehicle to collect the engine coolant, then disconnect the lower hose from the radiator.
 - 1072C44  exhaust manifold heat shield on bulkhead - r+r - 1092B50  alternator/air conditioner compressor drive belt - adjust tension - 1092C10  power steering and/or self-levelling suspension pump drive belt - r + r1. Undo the power steering pump retaining nuts.2. Move the power steering pump to one side without disconnecting both oil hoses.
1. Undo bolt (1a) securing the bracket to the crankcase and bolt (1b) securing the water pump to the crankcase.2. Remove the bracket.Raise the ramp.3. Loosen the lower alternator bolt.4. Tip the alternator down to gain access to the water pump fastenings.
1. Unscrew bolts (1a) securing filler pipe (1b).2. Unscrew the water pump bolts.3. Remove the water pump and mount.
Refitting ( Removing ) Fit the water pump and mount.Tighten the bolts securing the water pump to the crankcase to torque.

FasteningComponentØValue(daNm)
-BoltCOOLANT PUMPM62.5
Tighten the bolts securing the water pump to the rigid filler pipe to torque.

FasteningComponentØValue(daNm)
-BoltCOOLANT PUMPM62.5
Fit the bracket and tighten the bolts.

FasteningComponentØValue(daNm)
-BoltALTERNATOR SUPPORTM105
Tip the alternator up and tighten the bolt securing it to the mount.Tighten the alternator bolts to torque.

FasteningComponentØValue(daNm)
-BoltALTERNATOR ASSEMBLYM12 x 1.258.5
Fit the power steering pum in its seat.Tighten the power steering bolt and nut. - 1092C10  power steering and/or self-levelling suspension pump drive belt - r + r - 1092B50  alternator/air conditioner compressor drive belt - adjust tension - 1072C44  exhaust manifold heat shield on bulkhead - r+rConnect the lower radiator hose.- 1088A10 Engine COOLANT - Check density' and top up level, if necessary  - 4450B10  Front WHEEL (one) - R.R.With the ignition key in the off position, connect the battery negative terminal.Close the bonnet lid.Remove the vehicle from the ramp.