2584107 - 0010K20 20,000km service coupon, emission control version

Refitting ( Removing ) Position the vehicle on a lift.Check the tyre tread is not irregularly worn.

Some types of tyre are fitted with wear gauges; these tyres should be replaced as soon as these gauges are visible on the tread.

Do not swap tyres across.Check the tyre inflation pressure is correct. Also check the spare wheel.

The tyre pressures must be checked when they are cold.

Check that the lighting system is operating correctly: headlamps, turn signals, hazard lights, luggage compartment light, passenger compartment light, oddment compartment light and instrument panel warning lights.Check the windscreen wiper system is operating correctly and adjust the sprays if necessary.Check the front and rear wiper blades are correctly positioned and not worn.Remove the front wheels    Op. 4450B12 FRONT WHEELS (TWO) - R.R., then visually inspect the condition of the front disc brake pads and ensure they are not worn.Carry out a visual check of:body exteriorunderbody protectionrigid and flexible pipe sections (exhaust, fuel system, brakes)rubber components (gaiters, sleeves, bushes etc.)Check that the bonnet and boot are clean and that the linkage is clean and lubricated. Proceed with checking the tappet clearance and adjust, if necessary    Op. 1036H10 VALVE TAPPETS - CHECK AND ADJUST CLEARANCE Change the air cleaner cartridge    Op. 1048A14 AIR CLEANER FILTERING ELEMENT - REPLACE. Check and, if necessary, top up the engine coolant level.    Op. 0010T21 COOLANT - CHECK DENSITY AND TOP UP IF NECESSARYCheck and, if necessary, top up the brake fluid level.    Op. 0010T64 BRAKE AND/OR CLUTCH FLUID CHECK LEVEL AND TOP UP AS NECESSARYCheck and, if necessary, top up the windscreen washer fluid level    Op. 5050A14 RESERVOIR PLUG (IN ENGINE COMPARTMENT) OR WINDSCREEN WASHER FLUID LEVEL SENSOR - CHECK AND TOP UP IF NECESSARYCheck and, if necessary, top up the battery fluid level.Check and, if necessary, top up the power assisted steering fluid level    Op. 0010T71 POWER STEERING FLUID CHECK LEVEL AND TOP UP IF NECESSARYChange the engine oil and filter    Op. 0010T12 ENGINE OIL AND FILTER - REPLACE

For the 1.9 D version, the engine oil and filter should be replaced every 10,000 km.For the Multijet versions, the engine oil and filter should be replaced every 30,000 km or 24 months (*).(*) The actual interval for changing the oil and replacing the engine oil filter depends on the vehicle usage conditions and is signalled by the warning light or message, if present, in the instrument panel.

Replace the pollen filter    Op. 5010B09 PURIFYING (POLLEN) FILTER FILTER ELEMENT - REPLACE

The pollen filter should be replaced every 24 months.

Remove the vehicle from the lift.